2022 Volvo XC60 Problems And Complaints

Volvo XC60 user complaints and problems

The 2022 Volvo XC60 has faced a few complaints regarding its advanced safety systems and infotainment system. The previous models of the vehicle also faced similar issues with the driver-assist systems and electrical systems as well. However, the number of complaints faced each year is on the lower side denoting a solid reliability aspect of the XC60. Other issues faced by the XC60 in the recent past include power steering failures and premature brake warping issues.

Engine problems

• Sudden engine shutdown: The 2018 Volvo XC60 faced a couple of complaints regarding this issue. Among the two complaints, one stated that while the owner was driving the vehicle it behaved normally. The engine started to make ticking noises followed by a complete shutdown when the owner restarted the vehicle after parking it for some time. The vehicle started after several restart attempts but the check engine light stayed on. The other complaint stated that the engine shut down randomly while driving, rendering the electronics and the braking system of the vehicle useless as well.

Safety problems

• Rear automatic braking system malfunction: In the list of the Volvo XC60 problems, a single owner complained regarding this issue. The registered reports state that on multiple occasions the rear automatic braking system engaged while parking. There were no obstacles in the way of the vehicle while parking.
• Front collision avoidance system malfunction: A few isolated complaints were registered regarding this issue. In several cases, the front collision avoidance system failed to work as designed and resulted in a collision without any major injuries, however. In a few other cases, the system intervened without any reason while driving, risking the safety of the occupants.
• Premature wearing-out of brake pads: A few models from both the 2018 and 2019 model years of the XC60 faced this issue. All the reports mentioned that the front brake pads warped prematurely and repetitively, resulting in multiple replacements.

2022 Volvo XC60 recalls

The 2022 Volvo XC60 faced a single recall to date while the 2019 model year saw seven recalls, the highest number in the current generation of the SUV. The recalls issued by the brand covered almost all the major and even minor issues faced by the owners, however, the electrical system faults such as the infotainment issues never saw a single recall yet.

Recall Date	NHTSA Campaign ID	Component Affected	Recall Issue	Explanation
November 13, 2018	18V800000	ELECTRICAL SYSTEM	No GPS Location in the Event of a Crash	If the GPS location is not provided to emergency personnel it can inhibit emergency response in the event of a crash or injury.
January 18, 2019	19V046000	STRUCTURE	Tailgate Lifting Arms may Freeze and Separate	If the tailgate lifting arms separate, the arms could project rearward with significant force, increasing the risk of injury.
March 20, 2019	19V220000	SEATS	Front Seats may Move in a Crash	If the nuts are missing, in the event of a crash, the front seat structure and position may be affected, increasing the risk of injury.
August 25, 2020	20V503000	VISIBILITY, VISIBILITY/WIPER	Wipers may Loosen	The risk of the front wiper arms nut fixation to loosen and not holding the arm in the correct position, the wiper function could be reduced and vision could be impaired, thus increasing the risk of a crash.
September 5, 2018	September 5, 2018	EQUIPMENT	Risk of Shock or Fire from Charging Cable	An electrical shock or a fire can increase the risk of injury or death.
March 12, 2020	20V144000	FORWARD COLLISION AVOIDANCE	Automatic Emergency Braking May Not Engage	If the automatic emergency braking system does not engage as intended, it can increase the risk of a crash.
June 2, 2021	21V414000	ELECTRICAL SYSTEM, FUEL SYSTEM, GASOLINE	Low-Pressure Fuel Pump Fuse Can Fail	Failure of the low-pressure fuel pump can cause a stall, increasing the risk of a crash.
September 15, 2021	21V716000	SERVICE BRAKES, HYDRAULIC	Rotor and Shaft May Separate Causing a Loss of ABS	Separation of the rotor and shaft may cause a reduction in braking assistance and a loss of the Antilock Brake System (ABS) and Electronic Stability Control (ESC), increasing the risk of a crash.
January 7, 2021	21V001000	AIR BAGS, SEAT BELTS	SRS Control Unit Can Detach	A detached SRS control unit can decrease the performance of occupant protection systems such as airbags, seat belts, and high voltage battery disconnect, increasing the risk of injury during a crash.
September 1, 2021	21V682000	SEAT BELTS	Seat Belt Locking Retractor Malfunction/FMVSS 208	An unsecured child restraint system can increase the risk of injury during a crash.
September 15, 2021	21V716000	SERVICE BRAKES, HYDRAULIC	Rotor and Shaft May Separate Causing a Loss of ABS	Separation of the rotor and shaft may cause a reduction in braking assistance and a loss of the Antilock Brake System (ABS) and Electronic Stability Control (ESC), increasing the risk of a crash.

What model year of the Volvo XC60 to avoid?

The Volvo XC60 has been steady in its reliability department despite facing a few issues throughout its model years. The 2018 model year saw the introduction of a new generation of the XC60 while the number of complaints is quite low. Hence, avoiding a particular model year isn’t necessary in case you’re looking for a used Volvo XC60.

Should you buy a used Volvo XC60?

Definitely! The Volvo XC60 brings a host of standard safety techs along with superb levels of luxury. The reliability front of the XC60 is also dependable since the number of owners affected by the issues makes up a negligible percentage when compared to the total sales volume of the vehicles each year. While going for a used example of the XC60, make sure to perform an in-depth inspection of the vehicle and try to opt for a trusted used-car dealer as well for complete transparency.